Harley Davidson AIR INTAKE SYSTEM INSTALLATION INSTRUCTIONS

0

Filed Under (Harley Davidson) by admin on 08-04-2012

download
1. Preparing Vehicle a. Make sure vehicle is parked on level surface. b. Set parking brake. c. If engine has run in the past two hours, let it cool down. d. Disconnect negative battery terminal. e. Do not discard stock components after removal of the factory system. 2. Removal of stock system a. Stock air box configuration system. b. Release the four clips on the air box. c. Loosen the hose clamp on the turbo inlet pipe. d. Vehicle equipped with MAF sensor. Unplug the mass air flow (MAF) sensor. 4 d) Clamp removal. e. On vehicles equipped with IAT, unplug the IAT sensor and remove from the housing. f. Pull the air filter status meter from the grommet. g. Remove the rear section of the intake system. h. Remove the remaining stock air box system. 5 3. Installation of AEM® intake system. a. When installing the intake system, do not completely tighten the hose clamps or mounting hardware until instructed to do so. i. Use the supplied torx key to remove the MAF sensor. Save screws for later use. b. Install the supplied coupler as shown. c. Place the aluminum stand in the plastic member as shown.

Bridgestone 350 SPECIFICATION AND SERVICE MANUAL

0

Filed Under (Bridgestone) by admin on 03-12-2010

download
Engine ( 1 ) Type : ( 2 ) Piston Displacement : ( 3 ) Bore & Stroke : ( 4 ) Compression Ratio : ( 5 ) Max. Brake Horse Power ( 6 ) Max. Torque : ( 7 ) Air Intake System : ( 8 ) Starting System : ( 9 ) Charging System : (10) Ignition System: (11) Ignition Timing: (12) Spark Plug: (13) Carburetor: (14) Engine Lubrication: (15) Fuel: (16) Transmission Oil: Performance ( 1 ) Max. Speed : ( 2 ) Climbing Ability : ( 3 ) Fuel Consumption : ( 4 ) Min. Turning Radius : ( 5 ) Acceleration : (Standing Start 1/4 mile) (Zero to 60 mph) : ( 6 ) Braking Distance : Frame and Suspension (1) Frame: (2) Front Suspension: (3) Rear Suspension: 2-stroke, Dual Cylinders 344.9cc (21.5 cu-inches) 61 mm × 59 mm (2.40 × 2.32 inches) 9.31:1 40 HP/7500 rpm 4.0 kg-m/7000 rpm Rotary disc valve Kick Starter A. C. Generator Contact breaker gap : 0.3 – 0.4 mm (0.012 – 0.016 inches) Battery (25+1-2) degrees before T.D.C. N.G.K. B-8H, Electrode gap : 0.6 mm (0.024 inches) Type AMAL VM 26 SC Venturi: 26 mm Main Jet No.: 130 Throttle Valve Cut Away: 2.0 Air Jet : 2.0 Adjustment of Needle Jet : 0.6 Pilot Jet: 22.5Pilot Air Screw Position: 2 turns out Needle Position: 3 2 cycle oil Regular Gasoline 1.5 liter (2/5 US gal.) in transmission case SAE No. 10W/30 in all seasons or SAE No. 30 in summer and SAE No. 20 in winter 100-110 mph 1 in 2 94 mpg/25 mph (40 km/litre at 40 km/h) 2.25 m (7.38 feet) 13.7 sec 5.2 sec (Less than 12m at 50 km/h) 39 feet, at 30 mph Pipe Frame, Cradle Type Telescopic Fork with Hydraulic Damper Swinging Arm with Hydraulic Damper
Technical Data 2 Transmission ( 1 ) Clutch : ( 2 ) Transmission : ( 3 ) Gear Ratio : Dimensions and Weight ( 1 ) Overall Length : ( 2 ) Overall Width : ( 3 ) Overall Height: ( 4 ) Saddle Height : ( 5 ) Wheelbase: ( 6 ) Road Clearance : ( 7 ) Tire Size (Front) : (Rear): ( 8 ) Tire Pressure (Front) : (Rear): ( 9 ) Caster : (10) Trail: (11) Banking Angle: (12) Net Weight: (13) Fuel Tank Capacity: (14) Oil Tank Capacity : Electrical Equipment ( 1 ) Head Light : ( 2 ) Tail Light : ( 3 ) Stop Light : ( 4 ) Speedometer Lamp : ( 5 ) Tachometer Lamp : ( 6 ) Neutral Indicator Lamp : ( 7 ) 5th Gear Indicator Lamp : ( 8 ) Headlight High Beam Lamp : ( 9 ) Battery : Manual, Multiple discs, Dry type Constant mesh 6-speeds Primary (Helical Gear) 1:3.095 Gear Box: 1st 1:2.46 2nd 1:1.647 3rd 1:1.25 4th 1:1.00 5th 1:0.852 6th 1:0.759 Secondary (Chain) : 1:2.40 Total Gear Ratio : 1st 1:18.27 2nd 1:12.23 3rd 1:9.29 4th 1:7.43 5th 1:6.33 6th 1:5.64 2,110 mm (83.1 inches) 825mm (32.5 inches) 1,115 mm (43.9 inches) 810mm (31.9 inches) 1,375 mm (54.1 inches) 145 mm (5.7 inches) 3.25-19 4 ply 3.25-19 4 ply 2.0kg/cm2 (28-30 lbs/in2) 2.2 kg/cm2 (30-32 lbs/in2 ) 63° 105 mm (4.15 inches) 46° 165 kg (363 lbs) 15 litre (3-4/5 US gal.) Including 3.2 litre (4/5 US gal.) reserve 2.5 litre (3/5 US gal.) 12V-35/30W 12V-7W 12V-23W 12V-3W 12V-3W 12V-3W

Incoming search terms: