2003 – 2005 Matrix WIND NOISE FROM DOOR GLASS WINDOW RUN REPAIR

0

Filed Under (Toyota Manuals) by admin on 28-10-2011

download
NOTE: Use the same procedure for the LH side as the RH side. 1. Place the window in the down position. 2. Remove the window run. Completely remove the double-sided tape remaining on the frame. 3. Thoroughly clean the door frame using a white body shop towel and Kent Acrysol. NOTE: Do NOT use red shop towels. These towels contain silicone. 4. Install the door glass window run. A. Position the glass run at the No. 2 and No. 3 corners of the door frame and then attach the middle part of the run. B. Insert the glass run into the window run channels. NOTE: Do NOT apply water or lubricant to the glass run when inserting it into the door. Make sure the glass run fits securely into the holes of the door frame

2008 Matrix FRONT LICENSE PLATE MOUNTING BRACKET INSTALLATION DURING PDS

0

Filed Under (Toyota Manuals) by admin on 19-10-2011

download
Using the two self-tapping screws, install the mounting bracket to the front bumper. NOTE: Do NOT drill holes in the dimples. Tighten the driver’s side screw first and then tighten the passenger’s side screw. 3. Install the front license plate to the bracket using non-corroding self-tapping screws of the following size

2003 Matrix HEADLIGHT AMBIENT LIGHT SENSOR IMPROVEMENT

0

Filed Under (Toyota Manuals) by admin on 18-10-2011

download
in order to ensure excellent ambient light sensor performance in lower light situations (such as dusk and dawn), an updated Daytime Running Light Relay has been made available. 2003 model year Matrix vehicles produced before the VIN shown below. MODEL PLANT STARTING VIN Matrix TMMC 2T1*R3#E#3C072114 PREVIOUS PART NUMBERCURRENT PART NUMBER PART NAME QTY 82810-02030 82810-02033 Relay, Daytime Running Light 1 1. Remove and replace the Daytime Running Light Assembly. 2. Confirm proper headlight operation

2003 – 2008 Corolla, Matrix Front Brake Rattle Noise REPAIR

0

Filed Under (Toyota Manuals) by admin on 13-10-2011

download
The information contained in this TSB supersedes TSB No. BR004-07. •The Titlehasbeenc hanged from”Front Brake Squeak”to”Front Brake Rattle Noise”. •Applicability has been updated to include 2008 model year Corolla and Matrix vehicles. •Production Change Information has been updated with new VIN information. •Parts Information has been updated. •The Components illustration (Figure 1) has been updated. •Step 1intheRepair Procedure has been modified. TSB No. BR004-07 is Obsolete and any printed versions should be discarded. Be sure tore view the entire content of this service bulletin before proceeding. Introduction Some customers ma yexperiencea front brake rattle type noise when the car is traveling over bumps. Updated front disc brake cylinder (caliper) mountings and disc brake pad support plates are available to eliminate this condition

TOYOTA Steering Intermediate Shaft Knocking Noise

0

Filed Under (Toyota Manuals) by admin on 13-10-2011

download
Some 2009-2010 Corolla and Matrix vehicles ma yexhibitaclunk, pop, or knocking noise when turning the steering wheel to the left or right. Anew intermediate shaft has been developed to address this condition. Use the following repair procedure to remove and replace the steering intermediate shaft. Install a steering wheel lock to ensure the wheels are straight and the steering wheel is centered before removing the steering intermediate shaft. Make sure the steering wheel and front wheels remain stationary. Once the intermediate shaft is removed, do NOT allow the steering wheel to spin freely. 2. Remove the column hole silencer sheet

TOYOTA Engine Intermittent No Crank/ No Start REPAIR

0

Filed Under (Toyota Manuals) by admin on 11-10-2011

download
Some Highlander, Matrix, and RAV4 vehicles may intermittently exhibita”no crank”condition. The engine can usually be started after moving the shift lever to the Neutral position orby cycling the shift lever in and out of the Park position. Are vised neutral starts witch assembly is available to address this condition. Warranty Information OP CODE DESCRIPTION MODEL TIME OFP T1 T2 Highlander 0.9 Matrix 0.5 832131 R&RP ark/Neutral Position Switch Assembly RAV4 0.7 84540-42010 17 99 APPLICABLE WARRANTY •Thisrepairis covered under the Toyota Comprehensive Warranty. This warranty is in effect for 36 monthsor36,000 miles, whichever occurs first, from the vehicle’sin-service date. •Warranty application is limited to occurrence of the specified condition described in this bulletin.