TOYOTA/ LEXUS U150/ U250 TOYOTA/LEXUS U150/U250 PRELIMINARY INFORMATION Presented to you by Wayne Colonna Automatic Transmission Service

0

Filed Under (Toyota Manuals) by admin on 19-09-2011

Download
Starting at the beginning of production for the 2002 model year for Lexus and 2004 for Toyota, a spin-off of the U140/U240 Four speed transaxle, designated as the U150/U250 series was born. This transmission is classified as a 5 speed transmission, although it has 6 ratio’s possible in the Drive position. The U150/250 is very similar to it’s smaller brother, the U140, and actually uses some of the same parts. This Transaxles shift points, and shift feel are electronically controlled by a Powertrain Control Module. This is accomplished by the PCM monitoring engine load and adjusting solenoid duty cycle to match pressure rise and shift feel. The PCM also monitors the turbine and output speed sensors to calculate gear ratio and the Transmission Range Sensor for gear selection.

Incoming search terms:

Harley-Davidson Six Speed Transmissions FLH 2009 Up Champion Reverse Gear Installation Instructions

0

Filed Under (Harley Davidson) by admin on 17-02-2011

download
Preparation Remove Original Parts From Vehicle. 2.1 Purchase a small tube of Loctite #262 (red) for use later. 2.2 To torque the large gear: 2.2.1 Purchase Snap-On (or equivalent) filter tool. Part #: FWA62121. OR 2.2.2 Purchase Champion special tool – Part # RG-100-100 2.3 Drain the transmission oil. 2.4 Remove front and rear exhaust header pipe. 2.5 Remove the clutch release cover (right side). 2.6 Remove throw out bearing assembly. (to be reinstalled later without modification) 2.7 Remove the two nuts from the main and counter transmission shafts. WARNING : Do not attempt to push shafts into gearbox or remove the trap door – This can cause spacers inside the gearbox to be miss-aligned and lock up the gearbox when gears are installed and tightened. 2.8 Remove clutch push rod (to be replaced w/ Champion supplied rod) Note: For hydraulic clutch bikes, obtain Champion Part # RG-100-082, a longer push rod) Snap-On Part No: FWA62121 Snap-On Part No: FWA62121 Champion Part No: RG-100-100 Reverse Gear Installation Instructions Harley-Davidson Six Speed Transmission HD FLH 2009 Up Page 3 of 5 Revision 2 Boring Tool 3 Installation 3.1 Thoroughly clean threads of main and counter shafts using a silicon remover. 3.2 Apply the green thread locking compound (supplied) to main shaft threads and screw the small gear onto the main shaft. Figure 1 3.3 Install the supplied (ear)plug into the main shaft hole. To be removed later. 3.4 Install the supplied special tool to the small gear. Ensure the holes of the special tool align with the holes in the small gear. Figure 2 3.5 Install torque wrench to special tool and torque the small gear to 80 lb. ft. 3.6 Remove torque wrench from special tool. Do not remove special tool from small gear. 3.7 Using the supplied boring tool and the special tool as a guide, drill the main shaft through two holes of the special tool as shown. Stop when cutter contacts bearing race. Figure 3 3.8 Remove special tool, leaving main shaft plug in place, and thoroughly clean out the holes. Use care to ensure debris does not enter transmission. 3.9 Remove plug from main shaft hole. Figure 1 Figure 2 Figure 3 Note: To prevent gears from rotating during torque procedures, engage transmission into 1st gear and apply brakes Note: Frequently stop cutting and remove bit from hole to clean bit and vacuum debris from hole

KAWASAKI 1700cc Liquid-Cooled V-Twin Engine 6-Speed Transmission with Overdrive

0

Filed Under (Kawasaki) by admin on 13-12-2010

download
Kawasaki’s first production bagger model is ready to take the street by force. The new Vulcan® 1700 Vaquero™ motorcycle combines the authority of a massive 1700cc liquid-cooled V-Twin engine together with low-slung, streetwise styling of a frame-mounted front cowling and lower chin fairing, sleek side-opening hard bags, and a choice of stealthy Ebony or fiery Candy Fire Red monotone paint. Besides its unmistakable style, the Vaquero also includes a smooth-shifting 6-speed overdrive transmission, cruise control, a full-feature audio system, and a host of custom-designed accessories. Get ready to rumble. 1700cc Liquid-Cooled V-Twin Engine The Vulcan 1700 Vaquero’s 1700cc V- Twin bristles with low-rpm torque, ensuring immediate and potent acceleration. 6-Speed Transmission with Overdrive With its overdrive top gear, the Vaquero’s 6-speed transmission teams up with the V-Twin engine for a relaxed highway cruising experience. Frame Mounted Front Cowling Muscular front cowling features a cut-down windscreen for a minimalist look and uninterrupted airflow, and is frame-mounted for light handling. Side-Opening Hard Bags Holding an impressive 9.2 gallons of storage apiece, the side bags integrate neatly into the Vaquero™’s smooth, clean lines. Electronic Cruise Control Conveniently located on the right handlebar, the Vaquero’s standard electronic cruise control precisely maintains speeds between 30 and 85 mph. Full-Feature Audio System High-fidelity audio system features AM/FM and weather radio, and is can be accessorized with iPod players, XM Radio and CB radios. Multi-Function LCD Instrumentation Located on the Vaquero’s stylish “muscle car” inspired dashboard, the multi-function LCD instrumentation clearly organizes and presents all essential information.
Engine Four-stroke, liquid-cooled, SOHC, four valve per cylinder, 52° V-twin Displacement 1,700cc / 103.7ci Bore X Stroke 102 x 104mm Compression Ratio 9.5:1 Maximum Torque 108 lb-ft @ 2,750 rpm Cooling System Liquid, plus cooling fins Ignition TCBI with Digital Advance Induction Digital fuel injection, dual 42mm throttle bodies Transmission 6-speed with overdrive and positive neutral finder Frame Type Steel, double-cradle with box-section single-tube backbone Rake/Trail 30° / 7.0 in. Front Suspension / Wheel Travel 45mm hydraulic fork / 5.5 in. Rear Suspension / Wheel Travel Swingarm with twin air-assisted shocks, with 4-way rebound damping / 3.1 in. Front Tire Size 130/90×16 Rear Tire Size 170/70×16 Brakes, Front / Rear Dual 300mm discs, dual twin-piston calipers / Single 300mm disc, twin-piston caliper Overall Length 98.8 in. Overall Width 38.2 in. Overall Height 50.8 in. Seat Height 28.7 in. Curb Weight 835.7 lbs.** Wheelbase 65.6 in. Fuel Capacity 5.3 gal. Color Choices Ebony, Candy Fire Red Warranty 36 months Good Times™ Protection Plan 12, 24 or 36 months ** Curb weight includes all necessary materials and fluids to operate correctly, full tank of fuel (more than 90-percent capacity) and tool kit (if supplied

Incoming search terms:

ATK 605 Enduro SPECIFICATIONS

0

Filed Under (Atk) by admin on 16-11-2010

Model : ATK 605 Enduro
Year : 2001
Category: Enduro / offroad
Rating : 75.3 out of 100
Engine and transmission
Displacement: 597.00 ccm (36.43 cubic inches)
Engine type: Single cylinder, four-stroke
Power: 48.00 HP (35.0 kW)) @ 7200 RPM
Bore x stroke: 97.0 x 81.0 mm (3.8 x 3.2 inches)
Valves per cylinder: 4
Fuel system: Carburettor
Gearbox: 5-speed
Transmission type,
final drive: Chain
Chassis, suspension, brakes and wheels
Front suspension travel: 300 mm (11.8 inches)
Rear suspension travel: 330 mm (13.0 inches)
Front tyre dimensions: 80/100-21
Rear tyre dimensions: 110/100-18
Front brakes: Single disc
Front brakes diameter: 260 mm (10.2 inches)
Rear brakes: Single disc
Rear brakes diameter: 220 mm (8.7 inches)
Physical measures and capacities
Dry weight: 127.0 kg (280.0 pounds)
Power/weight ratio: 0.3780 HP/kg
Seat height: 925 mm (36.4 inches) If adjustable, lowest setting.
Wheelbase: 1,498 mm (59.0 inches)
Fuel capacity: 16.00 litres (4.23 gallons)

ATK NX 250 SPECIFICATION

0

Filed Under (Atk) by admin on 16-11-2010

Model: ATK NX 250 Category: Enduro / offroad Rating: Do you know this bike? Click here to rate it. We miss 2 votes to show the rating. Engine and transmission Displacement: 249.00 ccm (15.19 cubic inches) Engine type: Single cylinder, four-stroke Valves per cylinder: 4 Fuel system: Carburettor. Keihin 24mm Fuel control: DOHC
Ignition: CDI Lubrication system: wet sump Cooling system: Liquid Gearbox: 6-speed Transmission type,
final drive: Chain Clutch: wet plate Exhaust system: Supertrapp Chassis, suspension, brakes and wheels
Front suspension: WP USD Rear suspension: WP Multi Adjuster Shock Front tyre dimensions: 80/100-21
Rear tyre dimensions: 100/100-18 Front brakes: Single disc. 2-piston calipers Front brakes diameter: 24 mm (0.9 inches) Rear brakes: Expanding brake (drum brake) Physical measures and capacities Dry weight: 128.0 kg (282.2 pounds) Alternate seat height: 940 mm (37.0 inches) If adjustable, highest setting. Overall length: 1,473 mm (58.0 inches) Overall width: 820 mm (32.3 inches) Ground clearance: 323 mm (12.7 inches) Wheelbase: 1,473 mm (58.0 inches) Fuel capacity: 8.70 litres (2.30 gallons) Oil capacity: 1.80 litres (0.12 quarts) Other specifications Color options: Blue Frame – Red tank – White Fenders – 1 Inox radiatorcap Comments: Uses a Honda 4-stroke engine. Further information Parts and accessories Check out parts and

1972 Aermacchi Motorcycle 350 TV Engine and transmission SPECIFICATION

0

Filed Under (Aermacchi) by admin on 14-11-2010

Model: Aermacchi 350 TV
Year: 1972
Category: Classic
Rating: 67.5 out of 100. Show full rating and compare with other bikes
Engine and transmission
Displacement: 344.00 ccm (20.99 cubic inches)
Engine type: Single cylinder, four-stroke
Power: 27.00 HP (19.7 kW)) @ 7200 RPM
Top speed: 140.0 km/h (87.0 mph)
Compression: 9.0:1
Bore x stroke: 74.0 x 80.0 mm (2.9 x 3.1 inches)
Valves per cylinder: 2
Fuel control: OHV
Cooling system: Air
Gearbox: 5-speed
Transmission type,
final drive: Chain
Chassis, suspension, brakes and wheels
Front tyre dimensions: 3.00-19
Rear tyre dimensions: 3.50-18
Front brakes: Expanding brake
Rear brakes: Expanding brake
Physical measures and capacities
Weight incl. oil, gas, etc: 151.0 kg (332.9 pounds)
Fuel capacity: 15.00 litres (3.96 gallons)
Other specifications
Further information
Parts and accessories Check out parts and accessories from our other partners.
Ask questions Join the 72 Aermacchi 350 TV discussion group.
Insurance, loans, tests Check out insurance here. Search the web for dealers, loan costs, tests, customizing, etc

Incoming search terms:

Incoming search terms: